Material Safety Data Sheet
Diana Industries International, Inc.
15159 Goldenwest Circle
Westminster, California USA 92683
Phone 714-898-2311
Fax 714-898-1270
Order Desk 800-275-3951
PRODUCT:
KA-2000
DATE:
October 5, 1995
EMERGENCY TELEPHONE NUMBERS:
714-898-2311 or 800-275-3951
SECTION 1 - PRODUCT IDENTIFICATION
Trade Name:
KA-2000 Tar Remover
Formula #:
RF-0522645-A
Chemical Family:
DOT Hazard Classification:
DOT Shipping Name:
NFPA: Health:
2
Flammability:
2
Corrosiveness:
Reactivity:
0
SECTION 2 - HAZARDOUS INGREDIENTS
Hazardous Components:
Petroleum Distillate CAS # 64-742-88-7 100 ppm
Petroleum Distillate CAS # 64-742-47-8 100 ppm
Solvent Aromatic Naphta CAS # 64-742-95-6 50 ppm
SECTION 3 - PHYSICAL DATA
Boiling Point:
211 degrees F
Vapor Pressure (mm Hg):
Approx. .33
Vapor Density (Air=1):
ND
Solubility in Water:
Negligible
Appearance and Odor:
Light brown liquid, solvent odor
VOC:
Photoreactivity:
Specific Gravity (H2O=1):
.82
Percent Volatile:
Approx. 85%
Reactivity in Water:
None
pH:
Approx. 11
Evaporation Rate (BuOAc=1):
<1
VOC Composite Partial Pressure (mmHg):
SECTION 4 - FIRE AND EXPLOSION HAZARD DATA
Flash Point (Test Method):
110 degrees F
Extinguishing Media:
Foam, Dry Chemical, Water Spray
Special Fire Fighting Procedures:
Isolate fuel supply from fire. Use water spray to cool fire-exposed surfaces and to protect personnel. Avoid direct water spray.
Unusual Fire and Explosion Procedures:
Toxic gases or vapors may be released during fire or combustion
SECTION 5 - HEALTH HAZARD DATA
Threshold Limit Value of Product:
See section 2
Carcinogen:
No
Symptoms of Exposure and Routes of Entry
a. Eyes:
High vapor concentration is irritating to the eyes
b. Skin:
Frequent or prolonged contact may defat the skin, irritate and cause dermatitis.
c. Ingestion:
Small ingested amounts may cause pulmonary edema.
d. Inhalation:
High vapor concentration is irritating to the respitory tract. May cause dizziness, headache.
First Aid
a. Eyes:
Flush with water for 15 minutes. Consult a physician if irritation persists.
b. Skin:
Wash with soap and water. Remove contaminated clothing and footwear.
c. Ingestion:
Do not induce vomiting. Give plenty of milk or water. Contact a physician.
d. Inhalation:
Remove patient from exposure. Give proper ventilation. Consult a physician.
SECTION 6 - REACTIVITY DATA
Stability:
Stable
Incompatibility (Materials to Avoid):
Nitric acid, sulfuric acid, oxidizer
Hazardous Polymerization:
Will not occur
Hazardous Decomposition Products:
None
SECTION 7 - ENVIRONMENTAL PROTECTION PROCEDURES
Spill Response
a. Small Spill:
Collect materials, then mop up
b. Large Spill:
Dike area, contain material and prevent from entering sewer. Pump into a suitable holding tank for recovery. Eliminate sources of ignition and keep personnel away from spill.
Waste Disposal Method:
Contact local disposal company to treat as solvent waste
SECTION 8 - SPECIAL PROTECTION INFORMATION
Eye Protection:
Face shield or goggles
Respitory Protection (Specific Type):
Use approved NIOSH respirator in confined areas
Skin Protection:
Rubber gloves
Other Protection:
Plastic apron, safety shoes, eye fountain, stall showers
Ventilation Recommended:
Local exhaust is adequate. mechanical ventilation should be explosion proof.
SECTION 9 - SPECIAL PRECAUTIONS
Hygienic Practices in Handling & Storage:
Do not store near oxidizing substances
Other Precautions:
Keep containers closed and tight
Disposal of Empty Containers:
Do not re-use. Dispose of in accordance with local regulations
The above information is based on data of which we are aware and is believed to be correct as of the date hereof.
Since the information contained herein may be applied under conditions beyond our control and with which we may be unfamiliar and since data made available
subsequent to the date hereof may suggest modification of the information, we do not assume any responsibility for the results of its use.
This information is furnished upon condition that the person receiving it shall make his/her own determination of the suitability of the material for his/her particular purpose.